Overview
High-efficiency scale cleaners are advanced chemical solutions engineered to dissolve and remove mineral scale deposits (calcium, magnesium, iron oxides) from industrial systems. These formulations typically combine acids, chelating agents, and surfactants to penetrate and disrupt crystalline structures without damaging underlying metal surfaces. Modern variants emphasize environmental safety with biodegradable components and low-VOC formulations. They are classified by pH (acidic for carbonate scales, alkaline for silica/sulfate deposits) and application method (circulation, soaking, or spray).
Physical and Chemical Properties
Most commercial scale cleaners exhibit low viscosity (50-200 cP) for optimal flow through narrow passages. Acidic types (pH 1-3) often use phosphoric, sulfamic, or citric acids, while alkaline cleaners (pH 10-12) incorporate EDTA or gluconates. Redox-active formulations address iron oxide rust. Key performance metrics include scale dissolution rate (typically 0.5-2 mm/hour at 50°C) and metal corrosion rate (<0.1 mm/year for carbon steel). Some products contain corrosion inhibitors like benzotriazole for copper protection. Temperature stability generally ranges from 5°C to 80°C.
Main Applications
Primary industrial uses include boiler descaling in power plants (removing calcium sulfate deposits), cleaning heat exchanger tubes (eliminating fouling), and maintaining reverse osmosis membranes. The food/beverage industry employs NSF-approved variants for dairy equipment. In oil/gas production, these cleaners prevent downhole scaling in injection wells. Automotive applications include radiator maintenance. Emerging uses involve solar panel cleaning (removing hard water spots) and HVAC system maintenance.
Safety and Storage
Always store in HDPE or FRP containers away from oxidizing agents. Acidic formulations require secondary containment to manage potential leaks. Shelf life is typically 2 years when stored below 30°C. Operational safety mandates nitrile gloves, face shields, and acid-resistant aprons during handling. Neutralization kits (sodium bicarbonate for acidic cleaners, citric acid for alkaline) should be available onsite. Ventilation is critical when treating large systems to prevent vapor accumulation.
B2B Procurement Guide
Industrial buyers should specify: 1) Target scale composition (XRD analysis recommended), 2) System metallurgy (stainless steel, copper alloys etc.), 3) Required certifications (ISO 9001, NSF, or industry-specific standards). Bulk procurement (200+ gallons) typically reduces costs by 20-30%. Consider concentrate formulations (5:1 dilution ratio) for logistics savings. Evaluate suppliers with technical support for system-specific dosage calculations and waste disposal guidance.
Related Manufacturers
- 主营：[]
- 主营：[]
- 主营：[]
- 主营：400peg400、硅藻土、聚乙二醇、乳化剂、三乙醇胺、醚硫酸钠、聚氧乙烯醚、椰子油脂肪酸
- 主营：聚甲氧基二甲醚
- 主营：[]
- 主营：铁锈转化剂、电解抛光液、不锈钢光洁水
- 主营：氯化橡胶、高氯化聚乙烯、氯化石蜡、五金除锈剂、氯化聚丙烯、氯化聚氯乙烯、过氯乙烯、氯化EVA、氯磺化聚乙烯
- 主营：聚合硫酸铁、一水柠檬酸、葡萄糖酸、阻垢剂、除氟剂、除臭剂、泡沫清洗剂、酸性清洗剂、非氧化杀菌剂、氧化杀菌剂、过氧乙酸、硫酸铝、磷酸三钠、无水硫酸铝、液碱、高铁酸钾、洁厕灵、夜光粉、过硫酸钾、过硫酸铵、冰醋酸、氢氧化钾、吊白块、碳酸氢铵
- 主营：阻垢剂
- 主营：阻垢剂、阻垢缓蚀剂、反渗透阻垢剂、速效除垢剂、不锈钢清洗剂、反渗透碱性清洗剂、反渗透酸性清洗剂、换热器片清洗剂、中央空调清洗剂、重油污清洗剂、非氧化性杀菌剂、氧化性杀菌剂、杀菌灭藻剂、锅炉除氧剂、消泡剂、抑尘剂、预膜剂、防冻液
- 主营：除磷选、切削液、处理才、处理剂、清洗剂、去除剂、除味剂、除磷剂、除垢剂、清洗废、除臭剂、蒸发器、植物液、拉丝油、废垃圾、垃圾站、污水站、锅炉除、乳化液、喷淋塔、磷去除、重金属、除臭液、乳化油、超声波
- 主营：清洗剂、模具电解清洗剂、塑胶模具清洗液、模具专用水性防锈剂、光学玻璃清洗剂、五金除油除蜡剂、光纤半导体中性清洗剂、环保水基清洗剂
- 主营：工业清洗剂、水处理剂、缓蚀剂、钝化剂、锅炉化学清洗、锅炉除垢清洗
- 主营：缓蚀阻垢剂、杀菌灭藻剂、碱性反渗透阻垢分散剂、反渗透膜清洗剂、锅炉除垢剂、油田回注水阻垢剂、中央空调翅片清洗剂、预膜剂、蒸发器专用阻垢剂、反渗透膜还原剂、除臭剂、粘泥剥离剂、锅炉除氧剂、聚醚消泡剂、有机硅消泡剂、垃圾渗滤液阻垢剂、有机溴非氧化杀菌剂、铜缓蚀剂、采暖臭味剂、无磷缓蚀阻垢剂、反渗透絮凝剂、反渗透阻垢剂8倍浓缩、循环氨水破乳剂、聚合氯化铝PAC、聚丙烯酰胺PAM
- 主营：活性炭、聚丙烯酰胺、醋酸钠-乙酸钠、消泡剂、阻垢剂、除垢剂、杀菌灭藻剂、重金属捕捉剂、除磷剂、除臭剂、除氟剂、氨氮去除剂、工业葡萄糖、纤维球、复合碳源
- 主营：清洗剂、碳氢清洗剂、清洗冲压油、水基清洗剂
- 主营：白电油、洗板水、洗枪水、清洗剂、稀释剂、油墨稀释剂、油漆稀释剂、印刷油墨清洗、塑胶跑道稀释剂、塑料脱漆、异丙醇、无水乙醇、玉米级酒精、75%酒精、甲缩醛、二甲苯、碳酸二甲酯、乙酸乙酯、慢干水、香蕉水、乙酸甲酯、乙二醇
- 主营：硫酸锌、石膏粉、氧化镁、营养剂、食品彭松剂、饲料添加剂、硫酸镁、一水硫酸锰
- 主营：消泡剂、杀菌剂、阻垢剂、絮凝剂、清洗剂、重捕剂、除磷剂、破乳剂、除氟剂、除臭剂、重金属捕捉剂、缓蚀阻垢剂、飞灰螯合剂、粘泥剥离剂、油水分离剂、杀菌灭藻剂、钝化预膜剂、清洗除垢剂、漆雾凝聚剂、污泥脱水剂、反渗透阻垢剂、工业污水处理药剂、聚丙烯酰胺、聚合氯化铝、有机硫tmt-15
- 主营：磷酸三钠、工业级纯碱、全糖粉、阻垢剂、食品添加剂、软化水防垢剂、金属清洗除垢剂、水处理药剂、软水剂、缓冲剂、杀菌灭藻剂、磷酸钠试剂、除垢剂、阻垢型缓蚀剂、反渗透阻垢剂、工业葡萄糖、磷酸氢二钠、工业柠檬酸、柠檬酸、纯碱、小苏打、无水碳酸钠、工业纯碱、轻质碳酸钠、重质碳酸钠
- 主营：阻垢剂、反渗透阻垢剂、缓蚀阻垢剂、消泡剂、除磷剂、杀菌灭藻剂、絮凝剂、聚丙烯酰胺