Overview
Anionic flotation reagents are surface-active agents designed to selectively bind to negatively charged mineral particles during froth flotation. They play a critical role in mineral processing by increasing the hydrophobicity of target minerals, allowing them to attach to air bubbles and separate from gangue materials. Developed in the early 20th century, these reagents revolutionized ore beneficiation, particularly for sulfide ores. Modern formulations are tailored for specific mineral systems, with variations in chain length and functional groups to optimize performance under different pH and temperature conditions.
Physical and Chemical Properties
Most anionic flotation reagents are organic compounds featuring polar head groups (e.g., carboxylate, sulfate, or sulfonate) and non-polar hydrocarbon tails. Their effectiveness depends on ionic strength, pH, and the mineral's surface charge. In aqueous solutions, these reagents dissociate into negatively charged ions that adsorb onto positively charged mineral sites. Temperature stability varies; some degrade above 60°C. Compatibility with other reagents (e.g., frothers, depressants) must be tested to avoid interference in flotation circuits.
Main Applications
The primary use is in sulfide ore flotation, where reagents like xanthates and dithiophosphates are supplemented with anionic collectors for complex ores. They're also employed in non-sulfide systems, such as potash and oxide mineral recovery. In coal processing, anionic reagents help remove pyrite. Specialty formulations exist for rare earth elements and industrial minerals like fluorite. The choice depends on mineralogy, pulp chemistry, and environmental regulations, with some regions requiring biodegradable options.
Safety and Storage
While generally less toxic than cationic reagents, precautions are necessary. Powder forms may generate dust; liquids can spill. Store in corrosion-resistant containers away from oxidizers. Secondary containment is recommended for bulk storage. Shelf life typically exceeds 12 months if sealed properly. SDS sheets must be reviewed for specific handling instructions, as some formulations contain sulfur compounds that may emit hazardous gases under extreme conditions.
B2B Procurement Guide
When sourcing, specify: target mineral, desired recovery rate, and environmental compliance needs (e.g., RoHS). Bulk shipments (ISO tanks or drums) reduce costs for large-scale operations. Supplier audits are advised to verify consistency in active ingredient concentration. Trial batches should be tested under plant conditions. Contracts often include technical support for dosage optimization. Prices fluctuate with raw material (e.g., fatty acid) markets and logistics costs.
Related Manufacturers
- 主营：聚丙烯酰胺、聚合氯化铝、葡萄糖、浮选助剂、循环水药剂
- 主营：聚丙烯酰胺、污水处理絮凝剂、阳离子聚丙烯酰胺、阴离子聚丙烯酰胺、聚合氯化铝
- 主营：硫酸铝、除磷剂、沉降剂、混合器、絮凝剂、cod去除、滤水帽、活性炭、鹅卵石、石英砂、软水盐、制氮机、干燥剂、介质粉、覆盖球、排水帽、混凝剂、沉淀池、再生剂、填料球、阻化剂、吸附剂、净水剂、磁粉磁种、弹性填料
- 主营：聚丙烯酰胺、聚合氯化铝、醋酸钠、工业葡萄糖、聚合硫酸铁、磷酸三钠
- 主营：浮锡灵、铜萃取剂、氧化石蜡皂、橡胶助剂、uv助剂、铜矿活化剂、硫化锡矿石、苯乙烯膦酸、稀土矿捕收剂、锡石细泥捕收剂、表面活性剂、美狄兰捕收剂、中间体、光引发剂
- 主营：软水盐、水玻璃、磷酸三钠、无水亚硫酸钠、氢氧化钙、焦亚硫酸钠、草酸、柠檬酸、六偏磷酸钠、硼砂、液碱、三聚磷酸钠、片碱、磷酸、漂白粉、大苏打、碳酸钾、多聚甲醛、次氯酸钠、聚合氯化铝、元明粉、硼酸、氨水、二氯甲烷
- 主营：酸度调节剂、金属清洗剂、液体氯化锌、n甲基吡咯烷酮
- 主营：片碱、纯碱、过硫酸钠、硫化钠、磷酸、粒碱、氢氧化钾、氢氧化钠、氨基磺酸、亚硝酸钠
- 主营：硫酸镁、氟硅酸钠、草酸、硫脲浮选剂、硼酸、硼砂、柠檬酸铵、氯化钾、尿素
- 主营：脱硫催化剂、脱硫剂、888脱硫催化剂、硫泡沫助剂、PDS脱硫催化剂、沼气脱硫催化剂、焦化脱硫催化剂、脱硫脱氰催化剂、络合铁脱硫催化剂
- 主营：干强剂、中性施胶剂、表面施胶剂、造纸分散剂、湿强剂、淀粉降粘剂、纸张脱墨剂、纸张挺硬剂、石膏增强剂
- 主营：三元酸、二聚酸、太古油、矿石浮选剂、三乙醇胺、三乙醇胺油酸皂、油酸、三乙醇胺硼酸酯、十八胺、石油磺酸钠、石油磺酸钡、环烷酸、十二胺、工业级妥尔油、单油酸酯聚氧乙、妥尔油脂肪酸、聚醚胺、司盘80、吐温80、杀菌剂
- 主营：杀菌剂、椰子油、印染剂、阻燃剂、油酸锌、润湿剂、硫酸铯、催化剂、粘合剂、乳化剂、草酸锰、硫酸锂、石英砂、绝缘油、茶皂素、防腐剂、醋酸镁、锂电池、碘化锂、培养基、蒸馏水、硬脂酸、塑化剂、草酸钾、磷酸铁
- 主营：减水剂、分散剂、葡萄糖酸钠、聚合氯化铝
- 主营：橡胶油、增塑剂、工业尿素、分析试剂、生物肥料、水产养殖、硫代硫酸钠、大棚增温块、磷酸二氢钾、工业润滑剂、葡萄糖酸钠、食用葡萄糖、食品凝固剂、防冻液原液、水溶性糊精、液体硅酸钠、生物颗粒燃料、食用玉米淀粉、聚氨酯黑白料、改良土壤团粒、混凝土外加剂、植物油酸、苯甲醇、甘油、车用尿素
- 主营：碳酸丙烯酯、乙二醇二醋酸酯、油漆油墨稀释剂
- 主营：四氢呋喃、异丙醇、苯乙烯、三乙胺、乙酸乙酯、乙二醇丁醚、丙烯酸甲酯、二甲苯、dmf、丙烯酸、mibk、甲酰胺、正丙醇、环己胺、苯甲醇、peg溶剂、仲辛醇、乙二醇、异辛醇、叔丁醇、邻二甲苯
- 主营：优氯净、甘氨酸、磷酸硼、水杨酸、硫酸锰、苯甲醇、平平加、正辛烷、一乙胺、磷酸氢、白僵菌、蛋白胨、碳酸镁、磷酸铝、异丁酸、叔丁醇、硫化钡、木质素、醋酸钡、硫化钙、氯化锌、黄原胶、磺酸钙、氟化镁、异丙醇
- 主营：增塑洗涤剂、间二甲苯、乳化剂、防冻液、丙二醇、三甲苯、苯乙烯、溶剂油、钛酸四丁酯、甲醇、乙醇、仲辛醇、异丙醇、85磷酸、碳酸丙烯酯、甲基丙烯酸、丙烯酸羟乙酯、二甲苯、脂肪酸甲酯、甲酸、氨水、丙烯酸、草酸、聚乙二醇
- 主营：硫酸铜、二甲苯、均染剂、钼酸铵、液体肥、硫酸锌、乳化剂、锡酸钠、发黑液、叶面肥、混合菌、高碳醇、硫酸钴、络合剂、除油粉、糖醇锌、醋酸铜、氯化钾、壳寡糖、叔丁醇、清洗剂、糖醇硅、海藻硼、醋酸钴、防锈油